Nanofibers Prepared from PVA Solution Incorporated with ITO Powder by Electrospinning

Y. Z. Chen; Y. J. Pan; T. T. He; W. H. Hsing

Home / Archives / Vol. 19 No. 3 (2012) / Original Research Articles

Original Research Articles · 研究論文

Nanofibers Prepared from PVA Solution Incorporated with ITO Powder by Electrospinning

利用靜電紡絲法製備摻雜ITO粉末之PVA奈米纖維網

Y. Z. Chen 陳毓仁 Department of Textile Engineering, Chinese Culture University, *Department of Material and Fiber, Oriental Institute of Technology, **Key Laboratory of Eco-Textiles, Jiangnan University
Y. J. Pan 潘毅鈞 ✉ Department of Textile Engineering, Chinese Culture University, *Department of Material and Fiber, Oriental Institute of Technology, **Key Laboratory of Eco-Textiles, Jiangnan University
T. T. He 何婷婷 Department of Textile Engineering, Chinese Culture University, *Department of Material and Fiber, Oriental Institute of Technology, **Key Laboratory of Eco-Textiles, Jiangnan University
W. H. Hsing 邢文灝 Department of Textile Engineering, Chinese Culture University, *Department of Material and Fiber, Oriental Institute of Technology, **Key Laboratory of Eco-Textiles, Jiangnan University

Abstract

In this document, prepared by chemical co-precipitation of indium tin oxide(ITO) through electrospinning to form indium tin oxide(ITO)/ polyvinyl alcohol(PVA) nano-fibers, determined the viscosity and electrical conductivity then observed the fiber surface forming by scanning electron microscope system. This report showed that for the one hand, with the weight percent concentration of the PVA solution increasing , it was obvious inclined for the fibers molding. For another hand, the viscosity and electrical conductivity has increasing with the same doping content of ITO powder. Compared to the literature, the peak shape of indium tin oxide(ITO)through the X-ray diffraction and the powder appearance was detected by transmission transmission electron microscopy have proved that it does have a trace amount of tin doped indium oxide lattice structure, and it is a transition exists between corundum structure and the bixbyite structure.

Keywords

摘要

本研究利用化學共沉澱法製備出錫氧化物(ITO)，透過靜電紡絲法製備銦錫氧化物(ITO)/聚乙烯醇(PVA)奈米纖維，對溶液進行黏度及電導度測試，並使用掃描式電子顯微鏡(SEM)對纖維表面成形進行觀測。由實驗結果得知，隨著PVA重量百分比濃度之增加，纖維的靜電紡可紡性會有著明顯的下降。在PVA重量百分濃度增加，ITO摻雜量不變之條件下，紡絲溶液的黏度及電導度有顯著的提升效果。本實驗所紡製之奈米纖維經文獻比對XRD之峰型及TEM之粉末外觀檢測後證實，粉末確實存在著氧化銦摻雜微量錫之晶格結構，其晶型結構在鐵錳礦型結構及金剛砂型結構之過渡相存在。

關鍵字

Also in this issue

Full TOC →

The Influence of Sweat-drops and Lights on Emissivity of the Far-Infrared Knitted Fabric
Y. S. Zhou, W. H. Hsing
Assessment of Using Bagasse Compost to Made Activated Carbon
J. H. Lin, L. Tsui, W. H. Hsing
The Study of Electroluminescence Fiber Coating Uniformity
Y. T. Lu, W. H. Hsing, P. J. Chen, N. T. Lee
Preparation and Sustained Release Effect of Alginate Microspheres Containing Peppermint Essential Oil
W. T. Huang, G. S. Huang, C. R. Li, C. P. Chang
Taiwan Printed Fabrics and Hakka Culture Application of Fashion Design
U. H. Lin, M. L. Xiao

Full text 全文

PDF 全文 → Open Access

Issue: Vol. 19 No. 3 (2012)
Section: Original Research Articles
Pages: 124
Submitted: 2015-06-20
Published: 2015-06-20
ID: JHGT-15-050
Views: 2
Downloads: 0

引用 How to cite

Chen, Y. Z., Pan, Y. J., He, T. T., & Hsing, W. H. (2012). Nanofibers Prepared from PVA Solution Incorporated with ITO Powder by Electrospinning. Journal of the Hwa Gang Textile, 19(3), 124. https://www.jhgt.org.tw/article/view/49

@article{chen2012_49,
  author  = {Chen, Y. Z. and Pan, Y. J. and He, T. T. and Hsing, W. H.},
  title   = {Nanofibers Prepared from PVA Solution Incorporated with ITO Powder by Electrospinning},
  journal = {Journal of the Hwa Gang Textile},
  year    = {2012},
  volume  = {19},
  number  = {3},
  pages   = {124},
  issn    = {1025-9678},
  url     = {https://www.jhgt.org.tw/article/view/49}
}

TY  - JOUR
AU  - Chen, Y. Z.
AU  - Pan, Y. J.
AU  - He, T. T.
AU  - Hsing, W. H.
TI  - Nanofibers Prepared from PVA Solution Incorporated with ITO Powder by Electrospinning
JO  - Journal of the Hwa Gang Textile
T2  - 華岡紡織期刊
VL  - 19
IS  - 3
PY  - 2012
SP  - 124
KW  - electrospinning
KW  - polyvinyl alcohol
KW  - indium tin oxide
KW  - co-precipitation
SN  - 1025-9678
UR  - https://www.jhgt.org.tw/article/view/49
AB  - In this document, prepared by chemical co-precipitation of indium tin oxide(ITO) through  electrospinning to form indium tin oxide(ITO)/ polyvinyl alcohol(PVA) nano-fibers, determined the viscosity and electrical conductivity then observed the fiber surface forming by scanning electron microscope system. This report showed that for the one hand, with the weight percent concentration of the PVA solution increasing , it was obvious inclined for the fibers molding. For another hand, the viscosity and electrical conductivity has increasing with the same doping content of ITO powder. Compared to the literature, the  peak shape of indium tin oxide(ITO)through the X-ray diffraction and the powder appearance was detected by transmission  transmission electron microscopy  have proved that it does have a trace amount of tin doped indium oxide lattice structure, and it is a transition exists between corundum structure and the bixbyite structure.
ER  -

下載 .ris 下載 .bib

分享 Share